Objective To explore the effect of pyropheophorbide-a methyl ester-mediated photodynamic therapy (MPPa-PDT) on the apoptosis in human osteosarcoma cell line MG63 and the underlying mechanism. Methods Human osteosarcoma MG63 cells in logarithmic growth phase were divided into 4 groups: blank control group (control group), the MPPa treatment group (MPPa group), the light irradiation group (LED group), and MPPa-PDT treatment group (MPPa-PDT group). MPPa-PDT group and MPPa group were incubated with MPPa (0.75 μmol/ L) for 20 hours in dark condition; control group and LED group were incubated with equal volume of fresh medium for 20 hours in the same condition. After washing with PBS and replacement with fresh culture medium, LED group and MPPa-PDT group cells were exposed to light (4.8 J/cm2) for 120 seconds. After light exposure, all groups were cultured in dark condition again. Then cellular morphology changes were observed by an inverted phase contrast microscopy, endoplasmic reticulum morphology changes were observed by transmission electron microscopy, cellular apoptosis was detected by Hoechst33258 nuclear staining, cell apoptotic rate and the levels of Ca in cells were analyzed by flow cytometry, the expression of p-PERK, C/EBP homologous protein (CHOP), cleaved-Caspase-12 were assayed by Western blot. Results In MPPa-PDT group, the retracted and round cells were observed; Hoechst33258 nuclear staining showed nuclear condensation, fragmentation, and other typical apoptotic morphological changes; the cell apoptotic rate (48.76%±3.54%) was significantly higher than that of control group (5.04%±0.41%), MPPa group (5.33%±0.38%), and LED group (6.48%±0.46%) (P < 0.05); the levels of Ca2+ in cells (485.29±58.77) was also significantly higher than that of control group (97.24±4.77), MPPa group (97.95±6.30), and LED group (101.17±5.26) (P < 0.05); swelling endoplasmic reticulum was observed under transmission electron microscope; the expressions of p-PERK, CHOP, and cleaved-Caspase-12 gradually increased at 1, 3, and 6 hours after treatment respectively, which were significantly higher than those of the other groups (P < 0.05). There was no typical apoptotic morphological changes and endoplasmic reticulum morphological changes in control group, MPPa group, and LED group, and there was no significant difference in the above indexes among 3 groups (P > 0.05). Conclusion MPPa-PDT can significantly induce apoptosis in MG63 cells. The endoplasmic reticulum stress pathway is involved in the MPPa-PDT induced apoptosis.